Quote:
Originally Posted by Jim/GA
Have you set the charge rate down to 8 amps and measured the volts at the battery again?
It sounds like you really need a different ammeter. Call Bert's.
|
*****************************************
Thanks for your reply
I just did another test on the generator output.
Please note that the ammeter in the car does not work at all at this point.
I am using my Fluke 88 meter to see what the amperage is coming from the generator. I used another multi meter to check the voltage at the same time.
At a fast idle-
With high beam headlights ON-
voltage--6.50
amperage--7.2
All readings were pretty steady.
At a fast idle--
With headlights OFF-
voltage--Climbing to 8.4 volts
amperage--Also climbing to 11.0 amp (I had the engine for at least 20 minutes and the voltage and amperage did not go any higher)
I have moved the third brush in the generator as far as I could and it would only lower the amperage to about 10 amps at a fast idle.
Someone suggested that I place a jumper wire between the two connection studs in the terminal box on the firewall. I did that it it made no change in voltage or amperage.